1-20 ton gas/oil fired boiler
Capacity: 1-20 ton/h
Pressure: 0.7-2 Mpa
Fuel: Nature gas, coke oven gas, biogas, methanol, liquid propane gas, diesel, heavy oil, light oil, crude oil, etc.
Industries: Heat supplying, chemical, food, textile, printing and dyeing, cigarettes and tobacco, fodder, pharmacy, building materials, brewery, rubber, hospital etc.
7-70 MW gas/oil fired hot water boiler
Capacity: 7-70 MW
Pressure: 1.0-1.6 Mpa
Fuel: Nature gas, coke oven gas, blast furnace gas, carbon black off-gas, biogas, methanol, LPG, diesel, heavy oil, light oil, crude oil, etc.
Industries: Heat supplying, hospital, colleges and universities.
2.8-29mw coal fired boiler
Pressure: 1.0-1.25 Mpa
Fuel: Bituminous coal, lean coal, anthracite
Industries: Heating, hotels, schools, hospitals
horizontal thermal fluid heater
Capacity: 700 - 14000 kw
Pressure: 0.8 - 1.0 Mpa
Fuel: natural gas, coke oven gas, bio-gas，liquid propane gas, diesel, heavy oil, light oil, crude oil
Industries: Petroleum, chemical, chemical fiber, pharmaceutical, textile printing and dyeing, building materials, wood processing, vegetable oil processing and other industries
1-20 ton biomass fired boiler
Capacity: 1-20 ton/h
Pressure: 0.7-2.5 Mpa
Fuel: Biomass particles
Industries: Heating, chemical, food, tobacco, textile, printing and dyeing, feed, medicine, building material, wine, rubber, hospital
This section examines WHR opportunities from coke ovens, blast furnaces, basic Waste heat could be recovered from the hot gas exiting the coke ovens at The heat can be captured in a waste heat recovery steam boiler for conversion to
Blast furnace gas (BFG) is a by-product of blast furnaces that is generated when the iron ore is reduced with coke to metallic iron. It has a very low heating value, about 93 BTU/cubic foot (3.5 MJ/m3), It may be combined with natural gas or coke oven gas before combustion or a flame support with richer gas or oil is
Apr 10, 2013 - In the non recovery or heat recovery coke ovens this gas is burnt in the operated combustion units such as process heaters, and boiler etc, in the blast furnace in some plants where there is excess of CO gas availability.
Key words: Iron and steel enterprise; energy saving; waste heat recovery; recycling In the process of coking production, the temperature range of two energy to the whole plant steam pipe network, replace part of the coal-fired boiler, waste furnace cooling water, blast furnace gas sensible heat and hot air stove flue
The ovens are heated with a mixture of blast furnace-top gas and coke oven gas through a waste heat boiler it is also called heat-recovery cokemaking.
Sintering plant. Coke oven. Pig iron. Blast furnace. Crude steel. Basic oxygen furnace Coke oven gas recovery OG (Oxygen converter Gas recovery system).
Our company designs the coke oven gas/ blast furnace gas boiler that adopts structure, water tube system and superheater suspended on the roof of the boiler
Coke is the most important raw material fed into the blast furnace in terms of its effect on blast Figure 1: "Coke Side" of a By-Product Coke Oven Battery. In one case, the waste gas exits into a waste heat recovery boiler (Figure 3) which
Develop technologies to reform coke oven gas aiming at amplifying its hydrogen of technologies to capture - separate and recover - CO2 from blast furnace gas Sensible heat recovery from slag (example) Waste heat recovery boiler.
flue gas heat recovery scheme in the hot blast generating process resulted in a saving of The main fuel used for hot stove combustion is the Blast Furnace Gas. (BFG), which is enriched with Coke Oven Gas (COG) in order to get the required
Feb 4, 2019 - One of the factors that reduce the hot blast stove block efficiency is the of losses with the waste gases, the heat of which can be recovered and used for air preheating results in a reduction of the coke oven gas flow rate. .. of Waste Heat Recovery System to Improve the Performance of Blast Furnace.
Combined-cycle in cogeneration firing of recovery gases from iron and steelworks a gas turbine exhausting into a recovery boiler that feeds a steam turbine. from a mixture of recovery gases from a steel plant (blast furnace, coke oven and LD . The new combined heat and power plant under construction at BASF&39;s
gas from a Blast furnace stoves exits at a temperature of around 350 to 4000C. A lot of dome temperature of 13750C, the fuel (BF gas and Coke oven gas) gas
The gas produced in the BOF has a temperature of approximately 1200°C and a The resulting hot gas from the combustion is then used in a heat recovery boiler to by mixing with other by-product gases (coke oven gas, blast furnace gas).
A TRT process and system for recovering energy from blast furnace top gas in an or coke oven gas before combustion or a flame support with higher heating
It has a very low heating value, about 93 BTU/cubic foot (3.5 MJ/m³, because it consists of Coke Gas or Blast Furnace Gas Boiler in Steel Industry--ZBG The coke oven gas/blast furnace gas boiler adopts "" type layout, front suspening air pre heater, waste heat recovery unit, chimney, diesel fuel fired steam boiler, gas
Mar 4, 2010 - Develop technologies to reform coke oven gas aiming at amplifying Sensible heat recovery from slag (example). Waste heat recovery boiler.
Jan 17, 2005 - Non-recovery type Coke Oven gas based Waste Heat Recovery Boilers each and a 32 TPH Blast Furnace Gas Fired Boiler (BFGFB).
May 20, 2013 - lurgical fuel gases blast-furnace gas (BFG) dominates. Minor shares of . coke-oven gas (COG) with a LHV of 380 MJ/kmol are used in metallurgical bustion and heat transfer conditions in the double-fuel boiler and the losses . The recovered LD converter gas (LDG) is accumulated in a storage tank in